Last Updated: 02/03/2020

UPDATE: April 04, 2018

Project Status: Construction

Roof Replacement

The intent of this project is to replace the existing 35 year old, 165,000 ft² EPDM roofing system with a new one that will increase the overall thermal efficiency and provide a 20 year non-prorated warranty from the roofing manufacturer. The scope of this work will consist of the following:

  • The existing ballasted EPDM membrane roofing system shall be removed in sections that shall minimize rain infiltration exposure to the building.

  • Once the existing roof has been removed, the existing steel deck, insulation and plywood shall be inspected and any deteriorated sections shall be replaced on a unit cost basis.

  • Additional wood blocking shall be installed as shown on the plans and specifications.

  • An additional 3”of Polyisocyanurate board insulation will be added over the existing insulation in order to achieve an overall R-value greater than R-20.

  • The existing scuppers shall be enlarged to a minimum opening height of 4”.

  • The existing drains shall be upgraded with cast iron strainers.

  • Obsolete penetrations and a roof hatch that is no longer used shall be removed and covered.

  • Minor repointing of existing brick masonry walls above flashing shall be performed.

  • Thru wall ductwork for one of the roof top units HV5) shall be reworked in order to provide a warrantable penetration.

  • Exhaust fans with low curbs shall be raised to an elevation that allows for a minimum height of 8” between the top of the curb and the final roof elevation.

  • A new 60 mil ballasted roofing system shall be installed.

    City User Agency:  Madison Metro

    1st Advertisement of Bids: November 10, 2017 available on BidExpress
    Bid Due Date: December 15, 2017
    Pre-Bid Site Walk-though: Nov. 29, 2017 1:00 pm at the project site, Madison Metro Bus Garage, located at 1101 E. Washington Ave
    SBE Pre-Bid Meeting: Dec. 08, 2017 1:00 pm at 1600 Emil St., Madison, WI
    "All information regarding dates/times/locations are informational and should be verified with official bidding documents posted on Bid Express."

    Construction Start Date: Anytime after 4/1/18

    Expected Completion: May 2019

    Metro Bus Barn